2004 Ford F-250 Fuel/Propulsion System Problems
- 6
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 3 |
| 150–400k mi | 2 |
| 30–60k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
Tl* the contact owns a 2004 ford f-250. The contact stated that a cone fractured in the fuel pickup sender unit. The failure recurred numerous times. Also, the vehicle stalled while driving without warning. The contact coasted to the side of the road and the vehicle would not restart. The contact stated that the vehicle was towed more than once to grieco ford of delray beach (3000 s federal hwy, delray beach, fl…
ODI 11269219
Electrical System · Fuel/Propulsion System · Power Train
Reduced powered under a grade/load. Reduced acceleration. Bogs down, cannot reach speeds higher than 40-45 mph, up hill.
ODI 11271433
Fuel/Propulsion System
Tl* the contact owns a 2004 ford f-250. While driving approximately 45 mph, the vehicle stalled and the check engine warning indicator illuminated. The contact had to maneuver the vehicle to the shoulder. After approximately half an hour, the vehicle restarted, but stalled again six miles later. The vehicle was towed to the contact's residence. The vehicle was diagnosed by an independent mechanic who stated that the…
ODI 10914316
Electrical System · Fuel System, Diesel · Fuel/Propulsion System
My vehicle has being stalling while driving at 1st start up in the morning for over 3 weeks. The problem is now getting daily. I understand there is a recall 05s34 that has this problem with the ford diesels. My vehicle in currently broken down about 60 miles from my home. The auto repair shop thinks its a hiring harness to the ficm. *tr
ODI 10490409
Fuel/Propulsion System
Tl* the contact owns a 2004 ford f-250. The contact stated that the vehicle would not start. The vehicle was towed to dealer for diagnosis where the stated that they needed to replace the head gasket. The vehicle was repaired but the vehicle still would not start. The dealer then advised the contact that the fuel module needed to be replaced. The vehicle was not further repaired. The manufacturer was contacted but…
ODI 10472917
Fuel/Propulsion System
Tl* the contact owns a 2004 ford f-250 tdi. The contact stated that while driving 10 mph uphill and towing a boat, the vehicle stalled without warning. The vehicle was taken to the dealer. The technician was unable to diagnose the failure but stated that he found permatex gasket material in the fuel system, causing the injector o-ring to blow. The manufacturer was not made aware of the failure. The vehicle was not…
ODI 10543979