2004 Ford F-250 Fuel System, Diesel Problems
- 5
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 2 |
| 1–30k mi | 1 |
| 150–400k mi | 1 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine And Engine Cooling · Fuel System, Diesel · Vehicle Speed Control
Engine accelerates sporadically on its own. Engine occasionally dies at stop lights. Must keep brake pedal firmly pushed at stop as engine will suddenly accelerate. I have already replaced the turbo. The dealer says it could be many different things wrong. The 2003-2007 diesels are notorious for bad turbo, fuel injectors and a head bolt problem that requires removing the cab. I purchased this truck new and it now…
ODI 10618762
Electrical System · Fuel System, Diesel · Fuel/Propulsion System
My vehicle has being stalling while driving at 1st start up in the morning for over 3 weeks. The problem is now getting daily. I understand there is a recall 05s34 that has this problem with the ford diesels. My vehicle in currently broken down about 60 miles from my home. The auto repair shop thinks its a hiring harness to the ficm. *tr
ODI 10490409
Fuel System, Diesel
The problem began in july 2011. I own and bought new, a 2004 f-250 super duty crew cab four-wheel drive truck with a 6.0 liter engine. The problem started with hard cold starts. When it did start after three to four attempts, the engine ran extremely rough. After a few minutes, it would eventually level off. Throughout the day, the engine would start and stop without any problems. But after being parked overnight,…
ODI 10419752
Electrical System · Fuel System, Diesel · Steering
Tl* the contact owns a 2004 ford f-250 equipped with a diesel engine. The contact was driving at approximately 65 mph, when the vehicle suddenly shut off completely with no power steering. He was able to get the vehicle safely to the side of the road and had it towed to a repair shop. The mechanic at the repair shop replaced the wiring harness and one of the fuel injectors. However, the wiring harness shorted out…
ODI 10322680
Control Module (Tcm, Pcm) · Fuel System, Diesel
2004 ford f250 super duty king ranch. After reflash to repair an idle problem truck developed three very dangerous conditions. 1. Cruise stalled - going down hill at approx 55-58 the truck will stall without warning. No power steering or brakes. Reproducable on demand. 2. Downshift lockup - truck will lockup rear tires in excess of 30 feet if tow/haul mode is used. On first occasion it almost caused a major accident…
ODI 10074959