2004 Ford F-250 Power Train Problems
- 5
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 2 |
| 150–400k mi | 1 |
| 60–100k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Electrical System · Fuel/Propulsion System · Power Train
Reduced powered under a grade/load. Reduced acceleration. Bogs down, cannot reach speeds higher than 40-45 mph, up hill.
ODI 11271433
Power Train
I had replaced drive shaft twice and universals twice. Every couple of months the front end starts to shake and these parts have to be replaced.
ODI 10968613
Electrical System · Fuel System, Gasoline · Power Train · Service Brakes · Steering
Tl* the contact owns a 2004 ford f-250. The contact stated that the fuel lines were severely corroded and were leaking. As a result, the transmission failed while driving at 40 mph, causing the contact to use excessive force in order to drive the vehicle. The vehicle was not diagnosed or repaired. The contact replaced the power steering fuel line, one brake line, and one transmission fuel line. The manufacturer was…
ODI 10779797
Engine · Power Train
Ford f series and super duty pickups with 5.4 engines. My 2004 ford f-250 has an issue with leaking exhaust manifolds. When looking into this further while getting pricing, i found out that this was not an isolated issue and that it was a common occurrence due to a mistake in material used for the exhaust manifold bolts. So common that aftermarket suppliers are making replacement kits for the problem. The exhaust…
ODI 10523485
12v/24v/48v Battery · Alternator/Generator/Regulator · Engine And Engine Cooling · Gas Recirculation Valve (Egr Valve) · Power Train · Wiring
2004 ford f250. Consumer states faulty icp sensor or faulty egr valve *tgw the reverse planet gear in the transmission was replaced. The egr valve replaced three times, the egr cooler, oil cooler were all replaced. The r&r turbo intake was replaced twice, the turbo inner cooler, wiring harness on the engine, transfer case, ficm module were replaced. The alternator and battery were replaced three times, the valve…
ODI 10411072