FordF-2502016
  1. Ford F-250
  2. Problems
  3. 2016
  4. Fuel/Propulsion System

2016 Ford F-250 Fuel/Propulsion System Problems

6
Owner complaint records in our dataset

Records are owner complaints, not a measured failure rate.

Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.

Mileage in stored records

BandRecords
1–30k mi3
30–60k mi2

Complaint records

Owner-submitted complaint content, presented as stored.

  • June 28, 2019

    Engine · Fuel/Propulsion System

    Was driving down the road and the truck started leaking diesel everywhere. We took the truck to the dealership where they said that when the filter clogs the truck doesn't turn off it sprays fuel out of the top of the filter housing. This is dangerous as my wife was driving the truck and sitting in the truck for several minutes with it running not realizing it was leaking . It could have caught on fire.

    ODI 11228342

  • February 15, 2019 · 51,000 miles

    Fuel/Propulsion System · Unknown Or Other

    Code p20ba, reductant heater in def tank. It is a known problem but ford did not include my year model in the warranty recall. $1050.00 to repair. I see all over the internet with people having the same problem that i'm having.

    ODI 11180846

  • January 17, 2017 · 5,500 miles

    Fuel/Propulsion System

    Dealership reports a failure to the high pressure fuel pump. Repairs are $7900.00. Only 5500 miles on the diesel truck and is not covered under warranty. No warnings lights or alarms were given. After thorough research, this is a concerning problem, with ford/bousch.

    ODI 10948166

  • August 25, 2016 · 15,200 miles

    Engine · Fuel/Propulsion System

    Engine runs rough during exhaust regen. Typically when driving between 55-65, the diesel exhaust fluid warning appears. Almost a minute later the truck begins to make loud jack hammer noise and loses power. Feels very unsafe as you lose power for about 10 seconds.

    ODI 10898625

  • June 17, 2016 · 2,000 miles

    Fuel/Propulsion System

    The fuel tank sending unit is not guarded. Poor design, i have a fleet of ford trucks. I have a 2010 f250 currently in the shop, ford has a factory shield covering the exposed fuel lines. Ford is also not covering the repair under warranty. The dealership also stated this is not the first truck with this damage. Fuel was spraying on the exhaust for a while before it died.

    ODI 10876488

  • April 12, 2016 · 45,240 miles

    Engine · Fuel/Propulsion System

    09/05/2016 purchased 2016 ford. 11/24/16 fuel filter pluged, replaced at landers ford benton ar.12/23,2016 check engine light (codes p008a, low fuel pressure/ and p0170 , something to do wioth the fuel) took to donley forsd galion ohio. They were not sure what to do but sugested changing the fuel filters. Truck was under waranty but charged me to do so mileage was 27,486. 1/12/16 check engine light again took to…

    ODI 10860362