2015 Ford F-250 Fuel/Propulsion System Problems
- 11
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 11 stored complaint records:
- 0 indicate a crash
- 0 indicate injury
- 2 indicate fire
What owners report
- check engine · 7 records
- engine light · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 3 |
| 60–100k mi | 3 |
| 100–150k mi | 3 |
| 30–60k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine · Fuel/Propulsion System
Catastrophic engine failure caused by broken glow plugs.
ODI 11278786
Fuel/Propulsion System
Tl* the contact owns a 2015 ford f-250. While operating the vehicle, "diesel fluid low" was displayed, the vehicle switched to the d-rate mode, and would not accelerate past 50 mph. The contact indicated that the failure was due to a faulty def- heater. The d-rating indicated that the diesel exhaust fluid was low although it was recently filled. The cause of the failure was not determined. The manufacturer was…
ODI 11270607
Engine · Fuel/Propulsion System
Tl* the contact owned a 2015 ford f-250. While driving approximately 65 mph, the "low engine power" and "low fuel" messages appeared and the contact detected a burning odor coming from the engine compartment. The contact heard an explosion coming from the engine compartment, which he belived was the master cylinder. The contact then noticed flames under the hood and smoke trailing behind the vehicle. The contact…
Fire reported
ODI 11254063
Fuel/Propulsion System
The reductant heater and sensor assembly failed causing the check engine light to illuminate and the remote start to become disabled. The vehicle was stationary. The check engine light illuminated upon attempting to start the vehicle. The vehicle is generally driven in high-traffic situations and the danger was the potential for the vehicle to enter limp mode thereby causing a potentially dangerous traffic hazard.…
ODI 11180349
Fuel/Propulsion System
I have a 2015 ford f250 diesel. The check engine light came on. I had it checked and found out this is a recurring problem for ford. The code given was p20ba which is def tank reduntant heater failure. This has been a problem since 2011 for ford. I have less than 27000 miles on my truck but since it happened outside the 36 month warranty, my local dealer will not cover it. I contacted ford thru thier web site and…
ODI 11195457
Fuel/Propulsion System
After driving approx 1 mile on surface street leaving work, a grinding noise was heard from fuel pump under vehicle under driver location. After 30 seconds check engine light illuminated and low fuel pressure message appeared in message area. Then reduced power appeared in message window. It happened so quickly that it left me stranded in the middle of the street with traffic on both sides until police came by and…
ODI 11149799
Fuel/Propulsion System
Upon starting the truck and entering the road, there seemed to be an odor of gasoline. As i proceeded down the road it seemed as though the miles to empty computer number was falling faster than the distance traveled. At approx. A mile and a quarter to half i stopped at a stop sign to check on the odor. Putting the truck in park, i started to open the door. As i started to open the door, fire erupted from both sides…
Fire reported
ODI 11097309
Fuel/Propulsion System
This truck has had it's def system malfunctioning from the beginning. It shuts off the engine at random intervals, usually low speed, and displays shift to park. So far it will always restart. It never displayed any codes or turned on the check engine light until recently. When 'check engine' light finally came on, i hoped it would solve the stalling when repaired. I connected a code reader and got code p20ba, which…
ODI 11080699
Fuel/Propulsion System
July 21 2017 8:00 pm near chama new mexico pulling a 10,000 pound fith wheel trailer climbing a mountain pass the truck chimes flashes a warning and goes into reduced power mode with no previous warning ( very unsafe condition with location and warning) this diesel truck was designed to pull a trailer ??? After research we limped off of the mountain pass warnings were the flashed on the dash that to clean the…
ODI 11013865
Engine · Fuel/Propulsion System · Power Train
During the epa mandated exhaust regeneration cycle the vehicle begins to shudder uncontrollably along with power loss. This behavior began at around 5,500 miles and now does it at least every other exhaust regeneration. It happens on multiple lane country roads and city roads at around 50 to 60 miles per hour. It seems more specific to the regeneration cycle than any other driving condition or input. Temperature is…
ODI 10790561
Electrical System · Fuel/Propulsion System
The truck seemed to be running out of gas, surged, sputter, surge sputtered then quit running. I had 1/2 a tank. Had to cost the truck a crossed speeding traffic lanes and came to a stop on an over pass. Had the truck towed to the dealer. The dealer findings were a problem with the fuel pump and controller. The dealer stated when they enter the check engine code (p0627) into their wan, they shortly had a call from…
ODI 10694074